Food Establishment Inspection Report
Page 1  of ????????? 
KANKAKEE COUNTY HEALTH DEPARTMENT
 2390 W. Station Street
Kankakee, IL 60901
Phone: (815) 802 - 9410
Establishment
 YWCA KANKAKEE CHILD CARE CENTER 		License/Permit #
 KK205
Street Address
1086 E COURT ST
City/State
 KANKAKEE, IL 		ZIP Code
 60901
No. of Risk Factor/Intervention Violations 5
No. of Repeat Risk Factor/Intervention Violations 0
Date 03/01/2019
Time In 10:20 AM
Time Out 12:00 PM
Permit Holder
YWCA OF KANKAKEE 		Risk Category
H
Purpose of Inspection
ORIGINAL INSPECTION

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance    OUT=not in compliance    N/O=not observed    N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection    R=repeat violation 		Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury. Public health interventions are control measures to prevent foodborne illness or injury.
Compliance Status
 COS R

SUPERVISION

 
1 IN OUT     Person in charge present, demonstrates knowledge, and performs duties    
2 IN OUT N/A   Certified Food Protection Manager    

EMPLOYEE HEALTH

 
3 IN OUT     Management, food employee and conditional employee; knowledge, responsibilities and reporting    
4 IN OUT     Proper use of restriction and exclusion    
5 IN OUT     Procedures for responding to vomiting and diarrheal events    

GOOD HYGIENIC PRACTICES

 
6 IN OUT   N/O Proper eating, tasting, drinking, or tobacco use    
7 IN OUT   N/O No discharge from eyes, nose, and mouth    

PREVENTING CONTAMINATION BY HANDS

 
8 IN OUT   N/O Hands clean & properly washed    
9 IN OUT N/A N/O No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed    
10 IN OUT     Adequate handwashing sinks properly supplied and accessible    

APPROVED SOURCE

 
11 IN OUT     Food obtained from approved source    
12 IN OUT N/A N/O Food received at proper temperature    
13 IN OUT     Food in good condition, safe, & unadulterated X  
14 IN OUT N/A N/O Required records available: shellstock tags, parasite destruction    
Compliance Status
 COS R

PROTECTION FROM CONTAMINATION

 
15 IN OUT N/A N/O Food separated and protected    
16 IN OUT N/A   Food-contact surfaces: cleaned & sanitized X  
17 IN OUT     Proper disposition of returned, previously served, reconditioned & unsafe food    

TIME/TEMPERATURE CONTROL FOR SAFETY

 
18 IN OUT N/A N/O Proper cooking time & temperatures    
19 IN OUT N/A N/O Proper reheating procedures for hot holding    
20 IN OUT N/A N/O Proper cooling time and temperature    
21 IN OUT N/A N/O Proper hot holding temperatures    
22 IN OUT N/A N/O Proper cold holding temperatures    
23 IN OUT N/A N/O Proper date marking and disposition    
24 IN OUT N/A N/O Time as a Public Health Control; procedures & records    

CONSUMER ADVISORY

 
25 IN OUT N/A   Consumer advisory provided for raw/undercooked food    

HIGHLY SUSCEPTIBLE POPULATIONS

 
26 IN OUT N/A   Pasteurized foods used; prohibited foods not offered X  

FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES

 
27 IN OUT N/A   Food additives: approved and properly used    
28 IN OUT N/A   Toxic substances properly identified, stored, & used    

CONFORMANCE WITH APPROVED PROCEDURES

 
29 IN OUT N/A   Compliance with variance/specialized process/HACCP    

GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in appropriate box for COS and/or R      
COS
=corrected on site during inspection  
R
=repeat violation  
Compliance Status
 COS R

SAFE FOOD AND WATER

 
30   Pasteurized eggs used where required    
31   Water & ice from approved source    
32   Variance obtained for specialized processing methods    

FOOD TEMPERATURE CONTROL

 
33   Proper cooling methods used; adequate equipment for temperature control    
34   Plant food properly cooked for hot holding    
35 X Approved thawing methods used X  
36   Thermometers provided & accurate    

FOOD IDENTIFICATION

 
37   Food properly labeled; original container    

PREVENTION OF FOOD CONTAMINATION

 
38 X Insects, rodents, & animals not present    
39 X Contamination prevented during food preparation, storage & display X  
40   Personal cleanliness    
41 X Wiping cloths: properly used & stored    
42   Washing fruits & vegetables    

PROPER USE OF UTENSILS

 
43   In-use utensils: properly stored    
Compliance Status
 COS R

PROPER USE OF UTENSILS

 
44   Utensils, equipment & linens: properly stored, dried, & handled    
45   Single-use/single-service articles: properly stored & used    
46   Gloves used properly    

UTENSILS, EQUIPMENT, AND VENDING

 
47   Food & non-food contact surfaces cleanable, properly designed, constructed & used    
48 X Warewashing facilities: installed, maintained & used; test strips    
49 X Non-food contact surfaces clean    

PHYSICAL FACILITIES

 
50   Hot & cold water available; adequate pressure    
51   Plumbing installed; proper backflow devices    
52   Sewage & waste water properly disposed    
53   Toilet facilities: properly constructed, supplied, & cleaned    
54   Garbage & refuse properly disposed; facilities maintained    
55   Physical facilities installed, maintained & clean    
56   Adequate ventilation & lighting; designated areas used    

EMPLOYEE TRAINING

 
57   All food employees have food handler training    
58   Allergen training as required    
IOCI 17-356

Food Establishment Inspection Report
Page 2  of ?????? 
Establishments: YWCA KANKAKEE CHILD CARE CENTER Establishment #: KK205
Water Supply:   Public Private   Waste Water System:   Public Private
Sanitizer Type: Chemical PPM: CHLORINE 50-100 Heat: CHLORINE 50-100 °F
CFPM Verification (name, ID#, expiration date):
NICHOLAS BUSHEY
26927084
02/11/2030

01/01/1900

01/01/1900

 

TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
/MILK COOLER 41.00°F /COOKED TACO MEAT 155.00°F /COMBO COOLER 41.00°F

OBSERVATIONS AND CORRECTIVE ACTIONS
Item
Number 		Severity Violations cited in this report must be corrected within the time frames below.
3 PF ALL FOOD HANDLING EMPLOYEES MUST COMPLETE FORM 1-B OR THE EQUIVALENT. COMPLIANCE BINDER REPORTING SHEETS SHOULD BE COMPLETED BY NEXT INSPECTION.
5 PF 2-501.11: A FOOD ESTABLISHMENT shall have procedures for EMPLOYEES to follow when responding to vomiting or diarrheal events that involve the discharge of vomitus or fecal matter onto surfaces in the FOOD ESTABLISHMENT. The procedures shall address the specific actions EMPLOYEES must take to minimize the spread of contamination and the exposure of EMPLOYEES, consumers, FOOD, and surfaces to vomitus or fecal matter.
A CLEAN- UP KIT IS REQUIRED FOR CARPETED AREAS. ABSORBENT,PPE, AND DISINFECTANT. CLEAN - UP KIT SHOULD BE ESTABLISHED BY NEXT INSPECTION.
13 PF 3-202.15: FOOD packages shall be in good condition and protect the integrity of the contents so that the FOOD is not exposed to ADULTERATION or potential contaminants.
CAN FOUND DENTED ON SEAM. - COS (Correct By: Mar 1, 2019)
16 P 4-501.114 (A):  (A) A chemical SANITIZER used in a SANITIZING solution for a manual or mechanical operation at contact times specified under ¶4-703.11(C) shall meet the criteria specified under §7-204.11 Sanitizers, Criteria, shall be used in accordance with the EPA- registered label use instructions, and shall be used as follows: (A) A chlorine solution shall have a minimum temperature based on the concentration and pH of the solution as listed in the following chart in the Food Code.
DISH WASHER MUST MEET CHLORINE SPECIFICATION BETWEEN 50-100 PPM. CORRECTED ON SITE. COS
26 P 3-801.11 (B): (B) Pasteurized EGGS or EGG PRODUCTS shall be substituted for raw EGGS in the preparation of: (1) FOODS such as Caesar salad, hollandaise or Béarnaise sauce, mayonnaise, meringue, EGGnog, ice cream, and EGG-fortified BEVERAGES,  and IDPH Field Guide (2) Except as specified in ¶ (F) of this section, recipes in which more than one EGG is broken and the EGGS are combined.
DUE TO CHANGE IN CODE CURRENT EGGS MAY BE USED HOWEVER ALL FUTURE PURCHASES OF EGGS MUST BE PASTEURIZED. FAILURE TO COMPLY WILL RESULT IN THE DESTRUCTION OF THE EGG PRODUCTS. - COS (Correct By: Mar 1, 2019)
35 C 3-501.13: TIME/TEMPERATURE CONTROL FOR SAFETY FOOD shall be thawed: (A) Under refrigeration that maintains the FOOD temperature at 5°C (41°F) or less; or (B) Completely submerged under running water: (1) At a water temperature of 21°C (70°F) or below, (2) With sufficient water velocity to agitate and float off loose particles in an overflow, and (3) For a period of time that does not allow thawed portions of READY-TO-EAT FOOD to rise above 5°C (41°F), or (4) For a period of time that does not allow thawed portions of a raw animal FOOD requiring cooking as specified under ¶ 3-401.11(A) or (B) to be above 5°C (41°F), for more than 4 hours including: (a) The time the FOOD is exposed to the running water and the time needed for preparation for cooking, or (b) The time it takes under refrigeration to lower the FOOD temperature to 5°C (41°F); (C) As part of a cooking process if the FOOD that is frozen is: (1) Cooked as specified under ¶3-401.11(A) or (B) or § 3-401.12, or (2) Thawed in a microwave oven and immediately transferred to conventional cooking EQUIPMENT, with no interruption in the process; or (D) Using any procedure if a portion of frozen READY-TO-EAT FOOD is thawed and prepared for immediate service in response to an individual CONSUMER'S order. (E) REDUCED OXYGEN PACKAGED FISH that bears a label indicating that it is to be kept frozen until time of use shall be removed from the reduced oxygen environment: (1) Prior to its thawing under refrigeration as specified in(A) of this section; or (2) Prior to, or Immediately upon completion of, its thawing using procedures specified in (B) of this section.
FOOD FOUND BE BEING THAWED AT ROOM TEMPERATURE COS
38 C 6-501.111 (A) (B) (D): The PREMISES shall be maintained free of insects, rodents, and other pests. The presence of insects, rodents, and other pests shall be controlled to eliminate their presence on the PREMISES by: (A) Routinely inspecting incoming shipments of FOOD and supplies; (B) Routinely inspecting the PREMISES for evidence of pests; (D) Eliminating harborage conditions.
DROPPING FOUND IN DRY STORAGE AREAS (CORRECT BY NEXT ROUTINE INSPECTION)
39 C 3-305.11 (A) (B) (C): (A) Except as specified in ¶¶ (B) and (C) of this section, FOOD shall be protected from contamination by storing the FOOD: (1) In a clean, dry location; (2) Where it is not exposed to splash, dust, or other contamination; and (3) At least 15 cm (6 inches) above the floor. (B) FOOD in packages and working containers may be stored less than 15 cm (6 inches) above the floor on case lot handling EQUIPMENT as specified under § 4-204.122. (C) Pressurized BEVERAGE containers, cased FOOD in waterproof containers such as bottles or cans, and milk containers in plastic crates may be stored on a floor that is clean and not exposed to floor moisture.
PLATES FOUND STORED ON THE FLOOR IN THE DRY STORAGE AREA COS
41 C 3-304.14 (B)(1)(2): (B) Cloths in-use for wiping counters and other EQUIPMENT surfaces shall be: (1) Held between uses in a chemical sanitizer solution at a concentration specified under § 4-501.114; and (2) Laundered daily as specified under ¶ 4-802.11(D).
RAGS STORED IN SOAPY WATER, MUST BE STORED IN SANITIZER. CORRECT BY NEXT ROUTINE INSPECTION
48 C 4-303.11: SANITIZER SOLUTION MUST BE SET UP FOR WIPING SURFACES DURING ALL FOOD PREPARATION TIMES. CORRECT BY NEXT ROUTINE INSPECTION
49 C 4-601.11(C): (C) NonFOOD-CONTACT SURFACES of EQUIPMENT shall be kept free of an accumulation of dust, dirt, FOOD residue, and other debris.
1. RANGE CLEAN OUT NEEDS CLEANED
2.UTENSIL DRAWER NEEDS CLEANED
Correct by next routine inspection.
HACCP Topic: WHERE GLOVES WHEN HANDLING READY TO EAT FOODS AND PROPERLY WASH HANDS BEFORE DAWNING THE GLOVES. COMPLIANCE BINDER GONE OVER WITH P.I.C.
 

Person In Charge

  MS. VICKERS 		 

Date:

  03/01/2019
 

Inspector

  Ryan Wheeler 		 

Follow-up:  Yes   No   Follow-up Date: